SECTION 1. IDENTIFICATION
Product Name: Lithium Stearate
CAS #: 4485-12-5
Relevant identified uses of the substance: Scientific research and development
Supplier details:
Stanford Advanced Materials
E-mail: sales@samaterials.com
Tel: (949) 407-8904
Address: 23661 Birtcher Dr., Lake Forest, CA 92630 U.S.A.
SECTION 2. HAZARDS IDENTIFICATION
Classification
Classification under 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Label Elements
None required
Hazards not otherwise classified (HNOC)
May form combustible dust concentrations in air
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Component Lithium stearate
CAS-No 4485-12-5
Weight % 95+
SECTION 4. FIRST AID MEASURES
Eye Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes.
Skin Contact Wash off immediately with soap and plenty of water while removing all contaminatedclothes and shoes.
Inhalation Remove from exposure, lie down. Move to fresh air.
Ingestion Clean mouth with water. Get medical attention.
Most important symptoms/effects No data available.
Notes to Physician Treat symptomatically
SECTION 5. FIREFIGHTING MEASURES
Suitable Extinguishing Media Water spray. Carbon dioxide (CO 2). Dry chemical. chemical foam.
Unsuitable Extinguishing Media No data available
Flash Point No data available
Method - No data available
Autoignition Temperature No data available
Explosion Limits
Upper No data available
Lower No data available
Sensitivity to Mechanical Impact No data available
Sensitivity to Static Discharge No data available
Specific Hazards Arising from the Chemical
Dust can form an explosive mixture in air.
Hazardous Combustion Products
Carbon monoxide (CO) Carbon dioxide (CO2)
Protective Equipment and Precautions for Firefighters
As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or
equivalent) and full
protective gear.
NFPA
Health
0
Flammability
1
Instability
0
Physical hazards
N/A
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal Precautions Ensure adequate ventilation. Use personal protective equipment.
Environmental Precautions See Section 12 for additional ecological information.
Methods for Containment and Clean Up
Sweep up or vacuum up spillage and collect in suitable container for disposal
SECTION 7. HANDLING AND STORAGE
Handling Avoid contact with skin and eyes. Do not breathe dust. Do not breathe vapors or spray mist.
Storage Keep in a dry, cool and well-ventilated place. Keep container tightly closed.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Guidelines This product does not contain any hazardous materials with occupational
exposure limits
established by the region specific regulatory bodies.
Component ACGIH TLV OSHA PEL NIOSH IDLH
Lithium stearate TWA: 10 mg/m3
Component
Lithium stearate
Quebec Mexico OEL (TWA) Ontario TWAEV
TWA: 10 mg/m3
ACGIH - American Conference of Governmental Industrial Hygienists
Engineering Measures Ensure adequate ventilation, especially in confined areas.
Personal Protective Equipment
Eye/face Protection Wear appropriate protective eyeglasses or chemical safety goggles as described
by
OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard
EN166.
Skin and body protection Wear appropriate protective gloves and clothing to prevent skin exposure.
Respiratory Protection Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European
Standard
EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if
exposure limits are exceeded or if irritation or other symptoms are experienced.
Hygiene Measures Handle in accordance with good industrial hygiene and safety practice.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State Powder Solid
Appearance White
Odor No data available
Odor Threshold No data available
pH No data available
Melting Point/Range 220 °C / 428 °F
Boiling Point/Range No data available
Flash Point No data available
Evaporation Rate No data available
Flammability (solid,gas) No data available
Flammability or explosive limits
Upper No data available
Lower No data available
Vapor Pressure No data available
Vapor Density No data available
Relative Density No data available
Solubility No data available
Partition coefficient; n-octanol/water No data available
Autoignition Temperature No data available
Decomposition Temperature No data available
Viscosity No data available
Molecular Formula C18 H35 Li O2
Molecular Weight 290.41
SECTION 10. STABILITY AND REACTIVITY
Reactive Hazard None known, based on information available
Stability Stable under normal conditions.
Conditions to Avoid Incompatible products.
Incompatible Materials Acids, Bases, Strong oxidizing agents
Hazardous Decomposition Products Carbon monoxide (CO), Carbon dioxide (CO2)
Hazardous Polymerization Hazardous polymerization does not occur.
Hazardous Reactions None under normal processing.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute Toxicity
Product Information No acute toxicity information is available for this product
Component Information
Component LD50 Oral LD50 Dermal LC50 Inhalation
Lithium stearate 15 g/kg ( Rat ) Not listed Not listed
Toxicologically Synergistic
Products
No data available
Delayed and immediate effects as well as chronic effects from short and long-term exposure
Irritation No data available
Sensitization No data available
Carcinogenicity The table below indicates whether each agency has listed any ingredient as a
carcinogen.
Component CAS-No IARC NTP ACGIH OSHA Mexico
Lithium stearate 4485-12-5 Not listed Not listed Not listed Not listed Not listed
Mutagenic Effects No data available
Reproductive Effects No data available.
Developmental Effects No data available.
Teratogenicity No data available.
STOT - single exposure None known
STOT - repeated exposure None known
Aspiration hazard No data available
Symptoms / effects,both acute and
delayed
No data available
Endocrine Disruptor Information No data available
Other Adverse Effects The toxicological properties have not been fully investigated. See actual entry
in RTECS for
complete information.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
Do not empty into drains.
Persistence and Degradability No data available
Bioaccumulation/ Accumulation No data available.
Mobility No data available.
SECTION 13. DISPOSAL CONSIDERATIONS
Waste Disposal Methods Chemical waste generators must determine whether a discarded chemical is
classified as a
hazardous waste. Chemical waste generators must also consult local, regional, and
national hazardous waste regulations to ensure complete and accurate classification.
SECTION 14. TRANSPORT INFORMATION
DOT Not regulated
TDG Not regulated
Page 4 / 6
IATA Not regulated
IMDG/IMO Not regulated
SECTION 15. REGULATORY INFORMATION
International Inventories
Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL
Lithium stearate X X - 224-772-5 - X X X X X
Legend:
X - Listed
E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA.
F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA.
N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is
considered to cover the designated
polymer made with any free-radical initiator regardless of the amount used.
P - Indicates a commenced PMN substance
R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA.
S - Indicates a substance that is identified in a proposed or final Significant New Use Rule
T - Indicates a substance that is the subject of a Section 4 test rule under TSCA.
XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial
Updating of the TSCA Inventory Data Base
Production and Site Reports (40 CFR 710(B).
Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater.
Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a
specified list of low concern reactants
that comprises one of the eligibility criteria for the exemption rule.
U.S. Federal Regulations
TSCA 12(b) N/A
SARA 313 N/A
SARA 311/312 Hazardous Categorization
Acute Health Hazard No
Chronic Health Hazard No
Fire Hazard Yes
Sudden Release of Pressure Hazard No
Reactive Hazard No
Clean Water Act N/A
Clean Air Act N/A
OSHA Occupational Safety and Health AdministrationN/A
CERCLA
N/A
California Proposition 65 This product does not contain any Proposition 65 chemicals
State Right-to-Know N/A
U.S. Department of Transportation
Reportable Quantity (RQ): N
DOT Marine Pollutant N
DOT Severe Marine Pollutant N
U.S. Department of Homeland Security
This product does not contain any DHS chemicals.
Other International Regulations
Mexico - Grade No data available
Canada
This product has been classified in accordance with the hazard criteria of the Controlled Products
Regulations (CPR) and
the MSDS contains all the information required by the CPR
WHMIS Hazard Class B4 Flammable solid
SECTION 16. OTHER INFORMATION
Safety Data Sheet according to Regulation (EC) No. 1907/2006 (REACH). The above information is
believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The
information in this document is based on the present state of our knowledge and is applicable to the
product with regard to appropriate safety precautions. It does not represent any guarantee of the
properties of the product.
